Harley recalls bikes for ignition switch problem - 21 News Now, More Local News for Youngstown, Ohio -

Harley recalls bikes for ignition switch problem

Posted: Updated:
DETROIT (AP) - Ignition switch problems that have plagued General Motors and Chrysler have now turned up in the motorcycle business.

Harley-Davidson is recalling more than 3,300 FXDL Dyna Low Rider bikes because engine vibration can turn the switches from "on" to "accessory."

The recall covers motorcycles from the 2014 ½ model year. If the motorcycles have been modified to rev higher than 5,600 RPMs, an engine mount bracket can vibrate excessively, causing the problem.

If the switch goes to "accessory," the engine can shut off while being driven and potentially cause a crash. The company said there have been no crashes or injuries reported from the problem.

Dealers will replace the bracket assembly and ignition switch knob for free. Harley began notifying owners in late July.

Harley said in documents posted Friday by the U.S. National Highway Traffic Safety Administration that the motorcycles are limited at the factory to 5,600 RPMs, but Harley offers performance calibrations that let the engine rev higher than the limit. If the bikes hit 5,800 RPMs, the top engine mount bracket can vibrate too much and cause the ignition switches to malfunction.

The company said it began looking into the problem after its service department discovered that an ignition switch slipped out of the "on" position in testing. The company found four warranty claims and complaints about the problem, all in bikes with non-Harley exhaust systems.

The Milwaukee company's recall comes after General Motors recalled 17.3 million vehicles to fix problems with ignition switches that can cause engine stalling. Chrysler has recalled another 1.7 million for the same problem. So far this year the auto industry has recalled more than 40 million vehicles, passing the old full-year record of 30.8 million set in 2004.

Federal safety regulators in June began a broad investigation of ignition-switch and air-bag problems across the auto industry. That investigation is still open, although the agency wouldn't say if more automakers could be affected.

The investigation and recalls come after GM bungled an ignition-switch recall of older small cars. GM acknowledged that it knew of the ignition problem for more than a decade but failed to recall the cars until earlier this year, when it recalled 2.6 million small cars such as the Chevrolet Cobalt. Subsequent safety reviews caused GM to recall millions more vehicles for faulty switches.

Copyright 2014 The Associated Press. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.

  • More NewsMore>>

  • How you can help local food banks feed the hungry by simply voting on Facebook

    How you can help local food banks feed the hungry by simply voting on Facebook

    The Valley came through in a big way when WalMart offered to help the nation's food banks and now the challenge is back with a new fighting hunger initiative offering $60,000. You can help feed the hungry simply by voting each day until October 5th.WalMart has issued a "Fight Hunger, Spark Change," challenge. It is giving $60,000 to 50 food banks around the country that get the most votes.Second Harvest Food Bank of the Mahoning Valley says your vote will help feed up to $15,000 people each w...More >>
    The Valley came through in a big way when WalMart offered to help the nation's food banks and now the challenge is back with a new fighting hunger initiative offering $60,000. You can help feed the hungry simply by voting each day until October 5th.WalMart has issued a "Fight Hunger, Spark Change," challenge. It is giving $60,000 to 50 food banks around the country that get the most votes.Second Harvest Food Bank of the Mahoning Valley says your vote will help feed up to $15,000 people each w...More >>
  • Man steps in front of truck, sets himself on fire

    Man steps in front of truck, sets himself on fire

    Monday, September 15 2014 8:53 PM EDT2014-09-16 00:53:16 GMT
    OBERLIN, Ohio (AP) - Authorities say a man stepped in front of a passing truck on a northeast Ohio highway, was struck, then somehow managed to retrieve a container of gasoline, swallowed some and set himself on fire as three young children sat in his car.In a video posted online by The Chronicle-Telegram in Elyria, Ohio State Highway Patrol Lt. Travis Hughes says a passing motorist stopped and extinguished the blaze. The man was struck around 10:30 a.m. Monday on U.S. 20 in Oberlin, about 35...More >>
    OBERLIN, Ohio (AP) - Authorities say a man stepped in front of a passing truck on a northeast Ohio highway, was struck, then somehow managed to retrieve a container of gasoline, swallowed some and set himself on fire as three young children sat in his car.In a video posted online by The Chronicle-Telegram in Elyria, Ohio State Highway Patrol Lt. Travis Hughes says a passing motorist stopped and extinguished the blaze. The man was struck around 10:30 a.m. Monday on U.S. 20 in Oberlin, about 35...More >>
  • Route 318 bridge reopens in Mercer County

    Route 318 bridge reopens in Mercer County

    Monday, September 15 2014 8:47 PM EDT2014-09-16 00:47:19 GMT
    Route 318 is open to traffic in Shenango Township, Mercer County, following completion of a bridge replacement project.More >>
    Route 318 is open to traffic in Shenango Township, Mercer County, following completion of a bridge replacement project.More >>
  • Ohio/Pennsylvania NewsMore>>

  • Man steps in front of truck, sets himself on fire

    Man steps in front of truck, sets himself on fire

    Monday, September 15 2014 7:14 PM EDT2014-09-15 23:14:38 GMT
    OBERLIN, Ohio (AP) - Authorities say a man stepped into traffic on a northeast Ohio highway and then set himself on fire. Ohio State Highway Patrol officials say 28-year-old Hugo Ramos of Cleveland pulled to the side of the highway, stepped into the road and was hit by a truck. Ramos then got up, retrieved a container of gasoline from his car, swallowed some of it, poured the rest on his body and then set himself on fire as three children sat in his car. Officials say a bystander extinguishe...More >>
    OBERLIN, Ohio (AP) - Authorities say a man stepped into traffic on a northeast Ohio highway and then set himself on fire. Ohio State Highway Patrol officials say 28-year-old Hugo Ramos of Cleveland pulled to the side of the highway, stepped into the road and was hit by a truck. Ramos then got up, retrieved a container of gasoline from his car, swallowed some of it, poured the rest on his body and then set himself on fire as three children sat in his car. Officials say a bystander extinguishe...More >>
  • Police: Man lying in road struck by car, killed

    Police: Man lying in road struck by car, killed

    Monday, September 15 2014 10:29 AM EDT2014-09-15 14:29:55 GMT
    HERMINIE, Pa. (AP) - Authorities say a man apparently lying in the road in front of a western Pennsylvania high school was struck and killed by a car. Officials in Westmoreland County said the accident happened shortly after 1:40 a.m. Monday in front of Yough High School in Sewickley Township. State police said the pedestrian was apparently lying in the northbound lane of Lowber Road when he was hit by a car. Police said the driver reported seeing what appeared to be an object in the road an...More >>
    HERMINIE, Pa. (AP) - Authorities say a man apparently lying in the road in front of a western Pennsylvania high school was struck and killed by a car. Officials in Westmoreland County said the accident happened shortly after 1:40 a.m. Monday in front of Yough High School in Sewickley Township. State police said the pedestrian was apparently lying in the northbound lane of Lowber Road when he was hit by a car. Police said the driver reported seeing what appeared to be an object in the road an...More >>
  • Central Ohio teen shot to death

    Central Ohio teen shot to death

    Monday, September 15 2014 9:58 AM EDT2014-09-15 13:58:15 GMT
    COLUMBUS, Ohio (AP) - A central Ohio teenager was shot to death over the weekend. The Franklin County coroner identified the victim as 17-year-old Reb Barbee. Police say the teen was shot at about 5 a.m. Sunday in Prairie Township west of Columbus. Friends and neighbors told reporters that Barbee stumbled into his home leaving a trail of blood. The Franklin County Sheriff's Office hasn't released any details of the shooting and hasn't announced an arrest. Copyright 2014 The Associated Press....More >>
    COLUMBUS, Ohio (AP) - A central Ohio teenager was shot to death over the weekend. The Franklin County coroner identified the victim as 17-year-old Reb Barbee. Police say the teen was shot at about 5 a.m. Sunday in Prairie Township west of Columbus. Friends and neighbors told reporters that Barbee stumbled into his home leaving a trail of blood. The Franklin County Sheriff's Office hasn't released any details of the shooting and hasn't announced an arrest. Copyright 2014 The Associated Press....More >>
Powered by WorldNow
All content © Copyright 2000 - 2014 Worldnow and WFMJ. All Rights Reserved. For more information on this site, please read our Privacy Policy and Terms